DESIGN AND FABRICATION OF MAIZE-ON-COB TRAY DRYER
ABSTRACT
This study was carried out to generate a design data, design and fabricate a maize corn-on-cob tray dryer used by maize farmers. Ripped maize corns with husks were bought from the market and preserved to retained its moisture content, dehusked and thereafter, dried to a given percentage moisture content of 15%. This was done by laboratory dryer. The drying rate data was generated and the high rate of 2.0g/hr was used afterwards to design and fabricate the corn-on-cob dryer.
From the results, drying of a sample of maize corn-on-cob by the laboratory dryer took a period of three days and six hours to reach the 15% moisture content (wet basis) needed. A test run was carried out on the fabricated dryer and seventeen hours was used to dry a sample of maize corn-on-cob to the same 15% moisture content. This implies that design data is satisfactory as its application in the fabrication of the dryer resulted in an increased flow rate of air in the dryer thereby increasing the rate of drying at the same drying temperature of 40oC.
CHAPTER ONE
1.0 Introduction
1.1. Background of Study
Cereal grains have been and will continue to be a major source of food for humans and animals throughout the world. Amongst all cereals, the most important is the maize grain. (Leonard et al, 1963). Maize corn and products can be used for various purposes; human food, alternative medicine, chemicals, bio fuels, ornamentals, fodder, to mention but a few (Leonard, Warren H., and John H. Martin). Maize crop is intensively and extensively cultivated in all the geo-political zones of Nigeria. Early maize is planted between late March and late May while the late maize is planted between August and September.
The harvest time for the early maize is usually between late July and September. During this period, corns are harvested fresh and cannot be preserved by drying owing to the unavailability of sunshine during the rainy season. It is usually roasted or cooked fresh. This practice does not encourage maize farmers as they would sell the maize corn at a give-away prices and this does not guarantee returns on their investment. In addition to this, dried maize grains will guarantee food sufficiency during the scarce period. Notably, corn of high moisture content does not stored very well and is usually vulnerable to damage due to deterioration, molds, and insects during the period of storage.
However, open air-sun drying as practiced in most rural areas often yields poor quality dried corn, since the product is not protected against dust, moisture, wind, rodents as well as other domestic animals while carrying out the drying. As a result, they are often contaminated with pathogens. Another common practice in maize corn-on-cob drying is drying over a fire place. This has its own problems as the maize grains are contaminated with smoke. Moreover, the temperature of drying is not properly controlled such that grains become dead after drying. There are various research works that have been carried out on grain drying (Zare et al, 2006; Mellmann, et al 2011; Adzimah and Seckley, 2009). These works were silent on drying and dryer design for maize corn-on-cobs.
There are four major drying techniques; open air sun drying, fire wood /fuel drying, electrical drying and solar drying(Anyanwu et al 2006, Scanlin 1997 and Whitefield 2000). This research project will address these problems associated with postharvest handling of maize corn-on-cobs, in particular drying, by designing and fabricating electrically operated tray dryer that will be simple but very robust in operation.
1.2 Statement of the Problem
Maize corns are usually stored when dried to certain percentage moisture content. In Nigeria, maize corn drying is done in dry season because of low humidity of atmospheric air and adequate sunshine. However, it is a common place to see peasant maize farmers dry their maize corn-on-cobs over fire place, but this practice contaminates the dried maize corn with smoke and usually small quantity of maize corn-on-cob are dried. The reverse is the case during the rainy season.
Unfortunately, bulk of the maize corn is harvested in the rainy season and farmers can not dry the fresh maize corn rather they sell them at very cheap prices to corn roasters and for other delicacies. To give value to farmers and also to guarantee maize corn sufficiency during scarce period, it becomes necessary that a simple but robust corn-on-cob dryer should be designed and fabricated to assist farmers have good returns on their investment especially during post-harvest handling of maize corn during rainy season.
1.3 Objectives of the Research
The aims of this research include:
- To develop a drying rate curve for maize corn-on-cob at constant drying condition.
- To generate design data for tray dryer to be used to dry maize corn-on- cob.
- To develop and draw working diagrams for the tray dryer.
- To fabricate a tray dryer.
- To test run the tray dryer.
CHAPTER TWO
2.0 Literature Review
2.1 Introduction
The review of relevant literature is the main topic of this chapter. A literature review covers theoretical and methodological contributions to a certain issue in addition to the state of knowledge at the time of writing. It provides information about the state of the art in relation to the subject you are writing about. It examines the body of work on the chosen subject. The literature evaluation in this study comprises the …
Procedure for Downloading the PDF (Docx) Material
Design and Fabrication of Maize-On-Cob Tray Dryer can be downloaded by requesting the full set of materials at the project or seminar cost. The document will be sent via Microsoft Word (MS-Word) format via WhatsApp (e-mail) following payment confirmation.
| Seminar Material Cost ₦3,000 | Project Material Cost ₦5,000 |
Request Complete Material
 | Click here to request the Complete Material via WhatsApp including;
|
Disclaimer for Complete Material Utilization
The displayed research work titled "Design and Fabrication of Maize-On-Cob Tray Dryer" is stated as a research guideline towards accomplishing your assigned project / seminar research work. All the research materials on this website are ONLY for research purposes and should be used as a guideline in developing your research work. For no reason should you copy word for word as projectlist.com.ng will not be liable for any who copied the material. By ordering the complete research guideline, it signifies that you've accepted our terms of service.
Frequently Asked Questions (FAQ)
Is the topic “Revival Movement: A Catalyst for Church Growth” recommended for Theology and Biblical Studies Project?
Yes it is highly recommended — The study was carried out to scrutinize the Revival Movement Practice that serves as a Catalyst for Church Growth. Investigation revealed that most local churches are becoming cold due to a lack of outpouring of the Holy Spirit's power caused by sin or a lack of intimate fellowship with the Holy Spirit in the twenty-first century. Also, there is a challenge in measuring the growth of church through revival movement. The research design used in this report is descriptive design, utilizing questionnaire method to obtain information from the respondents for this project. Primary data were collected from the primary source which questionnaire was used as an instrument of data collection while secondary data were sources from textbooks, journals, newspapers and …
Can the material for “The Effect of Poverty on Educational Development of the Citizens” be used as a guide for Public Administration (PA) Project?
Yes it can be used — Poverty has been a serious problem facing all society over the years. This paper critically analyses the conceptual problems associated with poverty over the education of the citizens. It also analyses the causes of poverty and the various programme put in place for poverty alleviation such as family economic advancement. (feap) and poverty alleviation programme (pap) and various forms in which government has interfered. The question is, how far have these programmes served as veritable instrument of poverty alleviation in the country? This paper suggests that even though these measures have not achieved much as poverty alleviation instruments because of their operations deficiencies, they are nonetheless good instruments that could be improved upon. This research also has found out that …
Can the material for “The Linguistic - Stylistic Analysis of Nigerian Security Agencies Use of Language” be used as a guide for English Language Project?
Yes it can be used — Most of theories on the origins of language have all shown that language arose of man’s desire to adapt to his environment. For instance, the cooperation and contact theories show that language (speech) came into being out of the human instinct for survival and contact. One of the basic conditions that must be fulfilled before an individual can claim membership of any society is the ability to communicate effectively in the language of that society (community-social group). The norms and traditions of a society are transmitted through specific linguistic codes (language). This view is in consonance with Hallowell’s (1953) claim that: “A necessary condition for socialization in man is the learning and use of language and by the way, …
Can the material for “Governance and Strategy on Small Scale Enterprise in Nigeria” be used as a guide for Accountancy / Accounting Project?
Yes it can be used — This study assesses the financing option available to Small and Medium Scale Enterprises (SMEs) in Nigeria, using a total sample of 84 SMEs drawn from Benue and Nasarawa States as case study for a study period of 2007-2009. Mean scores and standard deviation were used to present and analyze the primary data obtained via questionnaires. Correlation was used to substantiate whether there is similarity in the inherent identified problems of each financing option. Simple percentages combined with mean scores were used to test hypothesis one while Chi-square was used to test hypothesis two. The result/findings show that SMEs are significantly financed by informal sources of finance than the formal sources of finance. Even SMEEIS, as a seemingly more organized formal …
Is the topic “Causes and Effect of Erosion” recommended for Agricultural Engineering (AE) Project?
Yes it is highly recommended — This research work was designed to examine the causes and effect of soil erosion in Ovia North East Local Government Area of Edo State. Five (5) research questions were formulated and questionnaires were administered to one hundred (100) respondents in order to gather data for the research. Results showed that agricultural activities lead to soil erosion, improper soil management cause erosion, deforestation lead to erosion etc. Recommendations were made and it include that; Sustainable soil management systems must be developed to reduce further degradation and restore the productivity of the eroded land. The management options to reduce the soil loss are to implement conservation measures and/or to change the crop to be planted. Soil conservation methods including terraces and bunds as well as …
Is the topic “Overview of Electronic Payment System in Nigeria-Acceptability and Retail Payment System” recommended for Computer Science Education Project?
Yes it is highly recommended — The use of electronic payment systems provide a lot of benefits to its users but despite these, the Nigeria economy is still regarded as cash-based where majority of its people prefer to carryout daily transactions with cash. The research was therefore conducted to examine the electronic payment options available in Nigeria and to determine the level of acceptance of electronic retail payment systems by Minna residents. The study employed primary data collected from a survey conducted in Minna metropolis through the use of questionnaire. The questionnaires which were administered to students, bank customers, and shops were used to determine the user acceptance of electronic retail payment system in Minna while secondary data from desk review of relevant documents was adopted to …
Can the material for “Effect of Privatization and Commercialization on the Nigerian Economy” be used as a guide for Economics Project?
Yes it can be used — The ultimate goal of any credible and legitimate government is to ensure sustained improvement in the standard of living of the citizenry. The government usually evolves development plans that will facilitate effective mobilization, optimal allocation and efficient management of national resources. Therefore, in trying to look into the effect of privatization and commercialization to growth of the economy and proffer a way forwards a positive state of privatization and commercialization of public enterprises in Nigeria. This five chapter’s research was emanated. In this research, the necessary statistical and econometric criterion that was employed in the evaluation of the model defined. The researcher applied statistical and econometric technique to evaluate the working hypothesis.And the result shows that privatization and commercialization has …
Can this topic “The Impact of Total Quality Management on Corporate Productivity in Nigerian Bottling Company” be used for Human Resource Management (HRM) Project?
Yes it can be utilized for research — This research work topic is Impact of Total Quality Management on corporate productivity in Nigerian Bottling Company, Kaduna. This begin with a brief background of the study that introduce the subject matter, also statement of the problem is also highlighted which is the reason why the researcher undertook the study to exploit such problems and come up with solutions, the objective of the study is discuss to see how total quality is important in the organization, in chapter two which is aimed in discussing the main body of the study which is review of literature. It consists of quality, quality determinants, the benefit of total quality management to the organization, and the challenges of total quality management, the researcher also …
Can this topic “Revenue Generation in Local Government Areas (Problems and Prospects)” be used for Public Administration (PA) Project?
Yes it can be utilized for research — The adverse situation in the various local government areas of Nigeria has led the researcher to go into this very topic. Hence, the purpose of this work is to enlighten people, mostly students in the school of financial studies on how revenue is generated in local governments, problems confronting them as regards revenue generation as well as prospects to the problems. However, local governments are expected to use the fund generated in embarking on income earning projects, projects, that come under fee or bill charging utilities like portable water, electricity, construction of market squares etc. However, before fund can be generated, one must make ways of getting the funds like grants given to local governments for some purposes by the federal government. …
Can the material for “Transposable Element in Bacterial Pathogenesis” be used as a guide for Microbiology Project?
Yes it can be used — Transposable elements are capable of switching their positions on the genome thereby causing gene arrangements and contributing to genome evolution. Transposable elements are mobile DNA sequences that are able to move within genomes. TEs display great diversity and are ubiquitous in living organisms, which led researchers to study their involvement in genomics. The study was carried out to examine the Transposable Element in Bacterial Pathogenesis. In achieving this aim, the following specific objectives were laid out to identify transposable elements in a wide range of organisms, provide useful tools for investigating the activity of transposable elements and proffer the problems of the above stated problems. Investigation revealed that the lack of general structural features makes them very difficult to identify. …