DESIGN AND CONSTRUCTION OF CONTROL SYSTEM FOR DIRECT-ON-LINE STARTING OF INDUCTION MACHINE
ABSTRACT
This project describes the methodical approach to the design and construction of Control System for Direct-On-Line Starting of Induction Machine. The procedures developed covers the construction of D.O.L stated for lower horse power motors. The prototype of this direct-on-Line starting of induction machine has been implemented following the methodical approach outlined in this project and its operational test and result are quite satisfactory. Adequate care has been taken in the design and construction of this project to ensure reliability. Therefore, the project is aimed at controlling the operation of single phase and three phase motors in industrial drive, companies, homes, laboratories and hospitals thereby reducing economic waste.
CHAPTER ONE
1.0 Introduction
Design and construction of control system for direct-on-line starting of induction machine: This is a control system that can control a single phase (1Ø) motors and three phase (3Ø) by making use of the components such as contactors, over current relay, start button, stop button etc. The contactors provides switching devices while over current relay is positioned to render protection to the machines in case of over current surge, the start and stop buttons called push buttons are used to start and stop the control contactor system. Again, there are pivot or indicator lamps which are controlled by normally open and normally closed of the auxiliary contacts incorporated to indicate when there is voltage supply to the three phase (3Ø) or single phase (1Ø) or both phases. However, the whole control system is controlled by mechanically pressing the push button ON and OFF when the circuit breaker has been switched ON.
The energy needed for the operation of the control system is three phase and one neutral through the input to produce single and three phase at the output terminal.
Finally the mode of operation is shown on the circuit diagram of the control system.
Organizational report:
- In chapter, 1 discussed about the background, aim, scope and limitation of the project.
- In chapter two, literature review of the project is discussed and elaborated.
- In chapter three, the design methodology (design Analysis, investigation and data) is discussed.
- In chapter four, construction, testing and packaging is described.
- In chapter five, Bill of Engineering measurement and evaluation (BEME) are stated.
- In chapter six, this is where the summary, conclusion and recommendation, reference and Appendices are stated.
1.1 Aims / Objective of the Study
The aims/object of embarking on the project are:
- To produce a system that will protect electric motor.
- To design a control system that will start induction machines without causing damage to the equipment.
CHAPTER TWO
2.0 Literature Review
2.1 Introduction
The review of relevant literature is the main topic of this chapter. A literature review covers theoretical and methodological contributions to a certain issue in addition to the state of knowledge at the time of writing. It provides information about the state of the art in relation to the subject you are writing about. It examines the body of work on the chosen subject. The literature evaluation in this study comprises the …
Procedure for Downloading the PDF (Docx) Material
Design and Construction of Control System for Direct-On-Line Starting of Induction Machine can be downloaded by requesting the full set of materials at the project or seminar cost. The document will be sent via Microsoft Word (MS-Word) format via WhatsApp (e-mail) following payment confirmation.
| Seminar Material Cost ₦3,000 | Project Material Cost ₦5,000 |
Request Complete Material
 | Click here to request the Complete Material via WhatsApp including;
|
Disclaimer for Complete Material Utilization
The displayed research work titled "Design and Construction of Control System for Direct-On-Line Starting of Induction Machine" is stated as a research guideline towards accomplishing your assigned project / seminar research work. All the research materials on this website are ONLY for research purposes and should be used as a guideline in developing your research work. For no reason should you copy word for word as projectlist.com.ng will not be liable for any who copied the material. By ordering the complete research guideline, it signifies that you've accepted our terms of service.
Frequently Asked Questions (FAQ)
Can this topic “Problems of Indiscipline on Academic Performance of Secondary School Students” be used for Education Project?
Yes it can be utilized for research — This study investigated the problems of indiscipline on the academic performance of secondary school students in Kosofe local government area of Lagos state. The study adopted descriptive survey research design. 196 secondary school students formed the sample while simple random sampling technique was used to select secondary school students from four Senior Secondary schools in Kosofe Local Government in Lagos State. Thirty Senior Secondary school students were randomly sampled from each school. A self-developed questionnaire of 21 items was used to collect information from the students after its validity was determined. Four hypotheses were tested in the study while Inferential Statistics of Pearson product moment correlation statistical tool was used for hypothesis testing at 0.05 levels of significance. The study revealed …
Can the material for “Design and Implementation of File Encryption and Decryption System” be used as a guide for Computer Science (CS) Project?
Yes it can be used — File encryption attempts to ensure secrecy in communications, such as those of spies, military leaders, and diplomats, but it have also had religious applications. The aim of the study is to design and implement a File Encryption And Decryption System. In achieving this aim, the following specific objectives of study were considered to design and develop an application software that will understand and improve the file data security through encryption of data, protect the pdf file (.pdf) from being viewed by third party using encryption and ensure the data confidentiality and integrity along with the safe transmission of file data over the web. The motivation that led to the implementation of the proposed system is that the password method used …
Can the material for “Frauds and Forgeries in the Nigerian Banking Industry” be used as a guide for Banking and Finance (BF) Project?
Yes it can be used — This study examines the impact of frauds and forgeries on the banking industry in Nigeria. One of the major characteristics a bank must possess is that its customers must be able to have unflinching and undoubted confidence in the banking the banking system, but due to the act of fraud and forgeries, this confidence has been reduced to the barest level, this does not affect the banking sector alone, but the long-term effect in on economy as good banking system helps to promote economic development. The primary source of data collection was used for this study. The simple random sampling was used to select 50 firms which serve as the sample size of the study. The chi-square statistical tool was …
Is the topic “Factors That Reduce Savings in Nigeria” recommended for Economics Project?
Yes it is highly recommended — This study investigates the core leading factors that reduces saving in Nigeria between 1980-2009, using ordinary least square(OLS) econometric framework, which will enable us proffer solution for the improvement of savings in the economy, which is also an important component for economic development in any country. Base on data collected, it is discovered that savings output in Nigeria during the period was unsatisfactory but was later discovered as a necessary factor for economic development and growth. This research shows the significance of savings which is achieved when saving habits is greatly considered by public, private and government. The empirical results show a negative influence of trade openness (TDO) on aggregate savings. The work therefore submits that effort should be geared …
Can the material for “Effect of Slide Game on Student’s Achievements and Interest in Algebraic Concepts” be used as a guide for Education Project?
Yes it can be used — The performances of students in mathematics, especially in external examinations like West African Senior School Certificate Examination (WASSCE/SSCE) and National Examination Council (NECO) have continued to deteriorate year by year. The conventional method used in teaching in our schools seems not to yield any positive results, and how to solve the problem has becomes a source of worry to mathematics educators. The nature of mathematics demands that it should be taught using activity based approach. If teaching methods which are activity based as suggested by psychologists like J. Bruner, J Piaget and Lev Vygotsky are used, then better results will be achieved. Therefore this study was designed to investigate the efficacy of the use of slide game approach on students’ achievements …
Can the material for “Techniques for Improving Workers Performance in an Industry” be used as a guide for Business Administration and Management (BAM) Project?
Yes it can be used — Managing employees in an organization is a function which everyone who has control over others share in human resources management. It is not be left to specialist alone because human materials resources and more difficult to manage than materials resources as a result of the conflict between the employers and employees wishes, so for a manager to be successful, he must understand and be able to use personal management techniques and in addition have some knowledge of the principles in industrial psychology on which they are based. He must be aware of the result of psychological studies of the employees as an individual nor a member of a working group and person who behaviour is influenced to some extent by …
Can this topic “The Impact of the Government Policies in Regulating the Activities of Insurance Companies in Nigeria” be used for Insurance Project?
Yes it can be utilized for research — The purpose of this research is concerned on the impact of the government policies in regulating the activities of insurance companies operating in Nigeria. The government responsibility to supervise, regulate and control the activities of insurance companies and intermediaries is to protect the interest of the insuring public and to save them from exploitation by unreliable insurers. Because of the intangible nature of insurance product, the government wants to make sure that those engaged in it must be competent person who will fulfill their promise and pledges when the need arises. Also because of the complexity of insurance business, it is necessary that the government regulate it to protect the policy holders. Also because of violation of public trust that occurs …
Can the material for “Difficulties Encountered by Students in Solving Algebraic Problem in Senior Secondary School” be used as a guide for Education Project?
Yes it can be used — This research work examined the Difficulties Encountered by Students in Solving Algebraic Problems in Surulere Education District of Lagos State. The design used for the study was a descriptive survey for collecting data from a sample of one hundred and twenty students and fifteen mathematics teachers from four senior secondary schools selected. The instrument used was questionnaires for students, questionnaires for teachers and diagnostic test for the students on algebra. Chapter one of this work is introduction which deals with the background of the study, research questions, significance of the study, scope and limitation of the study, chapter two include the literature review of the previous researchers, the importance of mathematics and algebra, difficulties students encountered in solving algebraic problems, effect …
Can the material for “Performance of English Language Learners (ELL) in Integrated Science Through Sheltered Instruction” be used as a guide for Integrated Science Project?
Yes it can be used — Integrated science plays a vital role in Nigerian Science Education programme because it prepares pupils at the Junior Secondary School level for a study of core science subjects at Senior Secondary School level which in turns brings about students’ interest in science oriented courses at the tertiary institutions. The purpose of the study was to verify the impact of Sheltered Instruction on ELL’s performance in some concepts in integrated science, performance of male and female ELLS, their attitude to science and students perception of Sheltered Instruction as an instructional strategy. As an experimental research design, the study population comprised all junior secondary school two students in Lagos. Out of this population, two intact classes were drawn from Educational District 1, …
Can the material for “Study of the Impact of Universal Banking in Nigeria Financial System” be used as a guide for Banking and Finance (BF) Project?
Yes it can be used — The study of the impact of universal Banking is one of the critical for banks Nigeria to attain greater light. This borders most no the effect of the New concept in Nigeria banking system that tends to remove the functional barriers between commercial and Merchant banks, and consequently empowers the bank to undertake part from their conventional banking business, capital market operations and insurance services. The chapter I stresses on the introduction. It equally deals with the background of study statement of problems, the objective of was based on exhuming the overall performance of the Nigeria banking system prior to the introduction of universal banking, research questions, significance and hypothesis to test. On chapter 2, the literate review was highlighted. Chapter three (3) …