THE PRODUCTION OF BIODIESEL (FAME) FROM PALM KERNEL OIL (PKO) USING CONCENTRATED SULPHURIC ACID AS CATALYST
CHAPTER ONE
1.0 Introduction
1.1 Background Of The Study
Biodiesel (fatty acid methyl esters) is an alternative fuel for diesel engines. It is an alcohol ester product from the transesterification of triglycerides in vegetable oils or animals accomplished by reacting lower alcohols such as methanol or ethanol with triglycerides.
The National Biodiesel Board (USA) technically defined biodiesel as a mono-alkyl ester. Blends of biodiesel and conventional hydrocarbon based diesel are products most commonly distributed for use in the retail diesel fuel market place. Biodiesel contain no petroleum, but it can be blended at any level with petroleum diesel to create a biodiesel blend. Much of the world uses a system known as the “B” factor to state the amount of biodiesel in any fuel mix:
- 100% biodiesel is referred to as B100.
- 20% biodiesel, 80% petrodiesel is labelled B20.
- 5% biodiesel, 95% petrodiesel is labelled B5.
- 2% biodiesel, 98% petrodiesel is labelled B2.
Blends of less than 20% biodiesel can be used in diesel equipment with no, or only minor modifications. Biodiesel can also be used in its pure form (B100), but may be blended with petroleum diesel at any concentration in most injection pump diesel engine. New extreme high-pressure (29000 psi) common rail engine have strict factory limits of B5 or B20 depending on manufacturers.
Biodiesel has different solvent properties than petrodiesel, and will degrade natural rubber gaskets and hoses in vehicles (mostly vehicles manufactured before 1992), although these tend to wear out naturally and most likely will have already been replaced with FKM, which is non reactive to biodiesel.
The first diesel engine was produced by Rudolf in Augsburg and Germany. In remembrance of this event, August 10 has been declared “International Biodiesel Day”. Rudolf diesel demonstrated a diesel running on pea nut (at the request of the French government) but for the French otto company at the world fair in Paris, France in 1990. (Knothe, 2001).
Biodiesel has been known to breakdown deposits of residue in the fuel lines where petrodiesel has been used. As a result, fuel filters may become clogged with particulates of a quick transition to pure biodiesel is made. Therefore, it is recommended to change the fuel filters on engine and heaters shortly after switching to a biodiesel blend.
Biodiesel is light to dark yellow liquid immiscible with water, with high boiling point and low vapour pressure. It has been used as a substitute for diesel fuel in the automobile industry and also referred to as a diesel — equivalent processed fuel derived from vegetable oils. (Biodiesel, 2007).
Several research have been performed on the production of biodiesel and some basic feedstock for the fuel includes animal fats, vegetable oils, soy, rapseed, jatropha, mahua, mustard, flax, sunflower, palm oil, hemp, field pennycress, pongamiapinnata and algae. Pure biodiesel is the lowest emission diesel fuel. Although liquefied petroleum gas and hydrogen have cleaner combustion, they are used to fuel much less efficient petrol engines and are not as widely available. Biodiesel is an oxygenated fuel, meaning that it contains a reduced amount of carbon and higher hydrogen and oxygen content than fossil diesel. This improves the combustion and reduces the particulate emission from un-burnt carbon. Biodiesel is also safe to handle and transport because it is as biodegradable as sugar, ten times less toxic than table salt, has a high flash point of about 300oF (148oC) compared to petroleum diesel fuel, which has a flash point of 125oF (52oC).
Current commercial production of biodiesel (FAME) is via homogeneous transesterification but this process has a lot of limitations, thus, making the cost of biodiesel not economical as compared to petroleum-derived diesel. One of the most significant limitations using this process is the formations of soap in the product mixture leading to additional cost required for the separation of soap from the biodiesel.
Also, the formation of soap has also led to the loss of triglycerides molecules that can be used to form biodiesel. However, since the catalyst and the reactants/products are in the same phase, the separation of products (biodiesel) from the catalyst becomes complex. On the other hand, heterogeneous transesterification can overcome all these limitations in which solid based catalyst is used in place of homogeneous catalyst, making it a more efficient process for biodiesel production with lower cost and reduced environmental impact.
Xie et al. studied the transesterification of soybean oil to methyl ester using potassium-loaded alumina catalyst. Also, Suppes et al. studied the transesterification reaction of soybean oil with zeolite and metal catalysts for the production of biodiesel, while Jitputti et al. studied the transesterification of crude palm kernel oil and crude coconut oil using several acidic and basic solids.
All these study indicated that different oils would require different catalyst for optimum conversion to biodiesel. {International Conference on Environment 2008 (ICENV 2008)
CHAPTER TWO
2.0 Literature Review
2.1 Introduction
The review of relevant literature is the main topic of this chapter. A literature review covers theoretical and methodological contributions to a certain issue in addition to the state of knowledge at the time of writing. It provides information about the state of the art in relation to the subject you are writing about. It examines the body of work on the chosen subject. The literature evaluation in this study comprises the …
Procedure for Downloading the PDF (Docx) Material
The Production of Biodiesel (Fame) From Palm Kernel Oil (Pko) Using Concentrated Sulphuric Acid as Catalyst can be downloaded by requesting the full set of materials at the project or seminar cost. The document will be sent via Microsoft Word (MS-Word) format via WhatsApp (e-mail) following payment confirmation.
| Seminar Material Cost ₦3,000 | Project Material Cost ₦5,000 |
Request Complete Material
 | Click here to request the Complete Material via WhatsApp including;
|
TABLE OF CONTENTSPRELIMINARY PAGES
- Title page
- Approval page
- Dedication
- Acknowledgement
- Table of Contents
- Abstract
INTRODUCTION
- 1.0 Introduction
- 1.1 Background …
- ⋮
LITERATURE REVIEW
- 2.1 Introduction
- ⋮
CHAPTER THREE
MATERIALS AND METHODS
- 3.1 Introduction
- ⋮
CHAPTER FOUR
RESULTS AND DISCUSSION
- 4.1 Introduction
- 4.2 Results
- ⋮
- 4.3 Discussion of Findings
CHAPTER FIVE
SUMMARY, CONCLUSION AND RECOMMENDATION
- 5.1 Introduction
- 5.2 Summary
- 5.3 Conclusion
- 5.4 Recommendation
REFERENCES
Disclaimer for Complete Material Utilization
The displayed research work titled "The Production of Biodiesel (Fame) From Palm Kernel Oil (Pko) Using Concentrated Sulphuric Acid as Catalyst" is stated as a research guideline towards accomplishing your assigned project / seminar research work. All the research materials on this website are ONLY for research purposes and should be used as a guideline in developing your research work. For no reason should you copy word for word as projectlist.com.ng will not be liable for any who copied the material. By ordering the complete research guideline, it signifies that you've accepted our terms of service.
PRELIMINARY PAGES
- Title page
- Approval page
- Dedication
- Acknowledgement
- Table of Contents
- Abstract
INTRODUCTION
- 1.0 Introduction
- 1.1 Background …
- ⋮
LITERATURE REVIEW
- 2.1 Introduction
- ⋮
CHAPTER THREE
MATERIALS AND METHODS
- 3.1 Introduction
- ⋮
CHAPTER FOUR
RESULTS AND DISCUSSION
- 4.1 Introduction
- 4.2 Results
- ⋮
- 4.3 Discussion of Findings
CHAPTER FIVE
SUMMARY, CONCLUSION AND RECOMMENDATION
- 5.1 Introduction
- 5.2 Summary
- 5.3 Conclusion
- 5.4 Recommendation
REFERENCES
Disclaimer for Complete Material Utilization
The displayed research work titled "The Production of Biodiesel (Fame) From Palm Kernel Oil (Pko) Using Concentrated Sulphuric Acid as Catalyst" is stated as a research guideline towards accomplishing your assigned project / seminar research work. All the research materials on this website are ONLY for research purposes and should be used as a guideline in developing your research work. For no reason should you copy word for word as projectlist.com.ng will not be liable for any who copied the material. By ordering the complete research guideline, it signifies that you've accepted our terms of service.
Frequently Asked Questions (FAQ)
Can the material for “The Need for Planning in an Organization” be used as a guide for Public Administration (PA) Project?
Yes it can be used — This project work is found out of principal factors responsible for the ineffectiveness of planning system in government organization. The objective of the study is to analyze the entire planning system of the organization under study, highlight areas of ineffectiveness in the organization for corrective measures and procedures. To determine whether the system provide effective reporting requirements to management for use in planning, controlling and future operation. To ascertain whether the planning system of mining organization comply with planning standards are under laid down regulations or not. The research work sill enable all department within the organization to acquaint themselves with the organization and other third parties to have knowledge on the system of keeping and maintain record of planning …
Can this topic “The Relationship Between Education and Socio-Economic Development” be used for Education Project?
Yes it can be utilized for research — This study attempted to investigate the effects of socio-economic status on student performance in commerce in educational district II in Shomolu Local Government Area of Lagos State. In this study related and relevant literature was reviewed. Also, survey research design was used in the assessment of the respondents’ opinion with the use of the questionnaire. A total of 200 (two hundred) students in five selected school were used as participants in this study. While the bio-data and research questions were analyzed with the use of the mean. At the end of the analysis, the following results were obtained: There is a significant difference between parental socio-economic status and students’ academic performance in senior Secondary Schools; and there is a significant …
Can the material for “Financial Ratios and Company Performances” be used as a guide for Business Administration and Management (BAM) Project?
Yes it can be used — The purpose of this study is to determine the role of financial ratio in analyzing the company performance using DN Meyer Plc as a case study. Data were collected from the company’s annual report from the period of 2001 to 2010. The following are the major findings from the research. The ability of the DN Meyer Plc to meet its maturing obligation was study using liquidity ratio. The current ratio is the only ratio used under this category. This shows that in 2001, the firm recorded 26.3:1, indicating that for every N1 spent as current liability is met with N26.30 in 2005, while it recorded 2.5:1 in 2009, and in 2010, it was 2.6. This clearly shows the performance of …
Can the material for “Impact of Vocational Guidance towards Students Decision Making in Tertiary Institution in Anambra State” be used as a guide for Vocational Education Project?
Yes it can be used — The study identifies the Impact of Vocational Guidance towards Students Decision Making in Tertiary Institution in Anambra State. In achieving this aim, the following specific objectives were laid out to investigate the impact of vocational guidance towards Students Decision Making, determine the extent to which vocational guidance has been able to influence Students Decision Making, determine the extent to which vocational guidance can practically reduce the level of unemployment among Tertiary Institution Students Leavers, determine the factors influencing career decision making, and determine the factors that affect the effective implementation of vocational guidance in Tertiary Institution in Anambra State. The research design used in this report is descriptive design, utilizing questionnaire method to obtain information from the respondents for this …
Can the material for “Problems and Prospect of Value Added Tax (VAT)” be used as a guide for Business Administration and Management (BAM) Project?
Yes it can be used — The topic value Added Tax, which was introduced in the year 1993, is a tax on consumption born by the final consumer by paying five percent (5%) on any valuable product whether local produced or imported. The researcher data collection was on two bases, which include the primary, and secondary. The primary data was the information got by the researcher when the researcher conducted on oral interview with the officials of the federal in land Revenue service, the Accountant General of Enugu state and some of his office staff, and Enugu North Local Government Council staff who are basically concerned with the collection and the disbursement of the money from value Added Tax. The secondary data was got from the value …
Can the material for “Effect of Poor Health on the Academic Performance of Secondary School Students” be used as a guide for Health Education Project?
Yes it can be used — The study was carried out to investigate the Effect of Poor Health on the Academic Performance of Secondary School Students in Oredo Local Government Area of Edo State. In achieving this aim, the following specific objectives were laid out to determine whether the nature of the school administration has influence the healthy habit exhibited by students and examine the influence of health conditions on academic performance of Secondary School Students in the area under review. Investigation revealed that a lot of factors are responsible for the poor health on the Academic Performance of Secondary School Students. The negligence of the school health services by the responsible ministries is attributable to the low level of academic performance and absenteeism in Secondary …
Can the material for “Insurance Industry and Risk Management in Nigeria” be used as a guide for Banking and Finance (BF) Project?
Yes it can be used — This research work looked at the insurance industry and risk management in Nigeria (A case study of NICON Insurance Corporation). It is aimed at X-raying the inherent problems associated with the adjustability and adaptability of risk management. The essence of risk management is to evaluate all pure risk exposures, insurable or uninsurable and develop the method for handling them. …
Can the material for “Design and Implementation of a Computerized Market Information System” be used as a guide for Computer Science (CS) Project?
Yes it can be used — This research is intended to highlight the role of a computerized market information system for the Nigerian breweries located in 9th Mile Corner Ngwo as compared too the manual method of market. The research goes a long way to identify the various problems associated with the organization and possible solution to the problems as to boast market structure. Also to highlight an overview of market by numerous authors as the back bone of profitability. …
Can the material for “Monetary Policy and Its Effects on Commercial Banking Operations” be used as a guide for Banking and Finance (BF) Project?
Yes it can be used — Monetary policy deals with the discretionary control of money supply, by the monetary authorities in order to achieve stated or desired economic objectives. This policy becomes necessary, as the government believes that a change in money supply has something to do with economic development. The researcher grouped the project into five chapters in order to carry out the study effectively. Analyzed in the first chapter, are the introduction of the subject matter, brief background study of commercial banks and their operations, among others. The objectives of the study, significance, scope and limitations of the study are exhaustively dealt with in this chapter. The second chapter however, deals with the review of related literature where the objectives of monetary policy are studies. Included …
Can the material for “In Vitro Antidiabetes Screening of Stecuria Satigera Steam Back of Crude and Chromatography Fractions” be used as a guide for Science Laboratory Technology (SLT) Project?
Yes it can be used — Crude oil or petroleum is a complex mixture of hydrocarbons representing several classes of compounds, the most important of these being alkanes, naphthenes and aromatics. Diabetes affects many metabolic pathways in different tissues, many of which are potential targets for drug treatment. Diabetes is characterized by hepatic and peripheral (muscle and adipose tissue) insulin resistance. The aim of the study is to determine the In-vitro Antidiabetes Screening of Stecuria Satigera Steam Back of Crude and Chromatography Fractions. In achieving this aim, the following specific objectives were laid out to determine the In-vitro Antidiabetes Screening of Stecuria Satigera Steam, adapt the existing methods for the characterization of crude oils and petroleum product fractions using elution liquid chromatography, analyse the fractions using …