DESIGN, CONSTRUCTION AND PERFORMANCE EVALUATION OF A SOLAR DRYING SYSTEM FOR CROPS
ABSTRACT
This research presents the design, construction, and analysis of the performance of a mixed-mode solar dryer for crops. A mixed-mode solar dryer utilizes direct solar radiation from the sun as well as input heat ducted from the solar collector inlet which is directly connected to the dryer. Such dryers have been shown to outperform passive solar dryers as it was also shown in this work using drying kinetics.
Tomatoes were dried in the drying chamber under the mixed-mode condition. The maximum dryer temperature obtained was 39.2, while the lowest relative humidity in the dryer was 32%. These conditions are shown to be only fair for drying of tomatoes as it prolongs drying time. The system's performance was largely affected by poor insolation and high heat losses during chosen drying days. Based on drying kinetics, a drying rate of 2.88units/day was obtained during the chosen drying days. With this rate, the dryer can dry 2kg of tomatoes within three days.
The dryer can reduce the moisture content of 1kg of tomatoes from 95% to 14% within 45 hours of drying time. The capacity of the dryer is 1kg of products per tray.
A simplified 2D transient heat transfer model of the temperature distribution in the drying chamber is presented. Results obtained show that material selection, insolation, and inlet temperature play a crucial role in the solar dryer performance.
CHAPTER ONE
1.0 Introduction
The use of solar drying systems for agricultural products to preserve fruits, vegetables and other crops has been proven to be cheap, reliable, and environmentally friendly. These solar dryers offer another option for processing vegetables and fruits under safe conditions that conform to standards. Some of the good qualities of these solar dryers are minimal maintenance cost, no fuel costs, time saving, occupying less area, improvement of the product quality, environmental protection, and control of required air condition.
The availability of satisfactory information regarding efficient solar dryers is lacking in many countries where the food processing methods like indirect solar drying are needed. To eliminate the risk of spoilage during drying and quality production of the products, indirect drying with forced convection air flow is one of the best options.
Although the solar air collector is a very important component in the solar drying system, much attention has not been drawn to it during dryer design. In principle, the performance of the solar dryer depends on several operating conditions such as the climatic condition, collector orientation, the thickness of the cover material, wind speed, length and depth of the collector, and the type of material used for the absorber.
For this reason, this research has dealt with the optimization of the design, material selection, and required parameters to enhance the efficiency of the designed solar dryer. Drying is one of the methods used to preserve food products for longer periods. Drying helps in the preservation of food, fruits, and vegetables for a long time with good quality. It is a process of moisture removal due to simultaneous heat and mass transfer.
Drying of most agriculture products, especially fruits and vegetables requires hot air in the temperature range of 40 – 60 degrees for safe drying. Direct solar energy coupled with the wind has been used to dry food for years. Sun drying of crops is the widest spread method of food preservation in a lot of African countries due to solar irradiation being very high for the most part of the year. There are some drawbacks relating to the traditional method of drying i.e. placing the crops on mats, trays or paved grounds and exposing the product to the sun and wind.
These include poorer quality food caused by contamination by dust, insect attack, enzymatic reactions, and infection by micro-organisms. This system is labor and time intensive as crops have to be covered at night and during bad weather, and the crops continually have to be protected from attack by domestic animals. Non-uniform and insufficient drying is noted, resulting in deterioration of the crop during storage in this method. Fierce drying problems occur especially in humid tropical regions where some crops have to be dried during the rainy season.
CHAPTER TWO
2.0 Literature Review
2.1 Introduction
The review of relevant literature is the main topic of this chapter. A literature review covers theoretical and methodological contributions to a certain issue in addition to the state of knowledge at the time of writing. It provides information about the state of the art in relation to the subject you are writing about. It examines the body of work on the chosen subject. The literature evaluation in this study comprises the …
Procedure for Downloading the PDF (Docx) Material
Design, Construction and Performance Evaluation of a Solar Drying System for Crops can be downloaded by requesting the full set of materials at the project or seminar cost. The document will be sent via Microsoft Word (MS-Word) format via WhatsApp (e-mail) following payment confirmation.
| Seminar Material Cost ₦3,000 | Project Material Cost ₦5,000 |
Request Complete Material
 | Click here to request the Complete Material via WhatsApp including;
|
Disclaimer for Complete Material Utilization
The displayed research work titled "Design, Construction and Performance Evaluation of a Solar Drying System for Crops" is stated as a research guideline towards accomplishing your assigned project / seminar research work. All the research materials on this website are ONLY for research purposes and should be used as a guideline in developing your research work. For no reason should you copy word for word as projectlist.com.ng will not be liable for any who copied the material. By ordering the complete research guideline, it signifies that you've accepted our terms of service.
Frequently Asked Questions (FAQ)
Can the material for “Local Production and It’s Impact in Nigeria Economy” be used as a guide for Economics Project?
Yes it can be used — The purpose of this study is to examine local production and its impact on Nigeria economy. This study adopted the survey, ex post facto and descriptive research design for both quantitative and qualitative analysis. It is ex-post facto research design in that the data generated were already put in place and are not subject to the manipulation of the researcher, this were data within the period of 1989 to 2014. This data were extracted from CBN statistical bulletin in CBN website and from the website of Food and Agriculture Organization of the United Nations (FAO). This study presumed that the economic development in Nigeria (represented by real GDP) is dependent on Total Local Production TLP (independent variable), Cashew production in Nigeria …
Can this topic “Large Scale Production of Rice and Beans and Economic Growth” be used for Economics Project?
Yes it can be utilized for research — This study evaluate the “Large production of rice and beans and the economic growth of Kogi State”. The specific objective were to: Ascertain the socio-economic characteristics and importance of “large scale of production of rice and beans and the economic growth of Kogi State”. Profitability of rice and beans and identify the major constrain to the production of beans and rice in Kogi State, and Nigeria as a whole unit. 60 respondence were selected and choosen for this intellectual work projecting the “large reduction of rice and beans and the economic growth of Kogi State and Nigeria and the economic growth of the state”. Well structured and validate questionnaires were administer to obtain information presentation from the state department on …
Can the material for “The Effect of Interest Rate on Savings in Nigeria” be used as a guide for Insurance Project?
Yes it can be used — This study examined the effect of interest rates on savings in Nigeria Using multiple regression analysis. The study also carried out some diagnostic tests like heteroskedasticity, serial correlation test and stability test. This work made use of secondary data sourced from the central bank of Nigeria statistical bulletin from 1981 to 2014. The result of this regression analysis showed that the coefficient of interest rate was positive and the level of significance, 0.05 was less than the p-value so interest rate has a positive but insignificant relationship with savings in Nigeria. The control variable used (GDP and government expenditure) also showed positive but insignificant relationship with savings. This simply means that interest rate has no significant effect on savings in …
Can the material for “Problems and Prospects of Information and Communication Technology (ICT) and It’s Effect on Secretaries” be used as a guide for Office Technology and Management (OTM) Project?
Yes it can be used — This project titled “Problems and Prospects of Information and Communication Technology (ICT) and its Effects on Secretaries” a case study of Federal Polytechnic Nasarawa was carried out to evaluate the problems and prospect of ICT and how it affects the Secretary as he carries out his duties. The Research questions used were, what are the problems associated with ICT? What are the effects of ICT on the Secretary's performances? Relevant literatures were reviewed. The instrument used in carrying out this research work was the administration of structured questionnaires; data collected was analyzed based on the four likert scale using mean to analyze the data. Based on findings, conclusion was drawn among others that the major problems faced by Secretaries as …
Can this topic “Management of Fraud and Wastage in Business Organization: Implication for Internal Auditors” be used for Accounting Technology Project?
Yes it can be utilized for research — This study is on management of fraud and wastages in business organizations: implications for internal auditor. Many objectives were set among which are: to identify the nature, types and major causes of fraud and wastages. Two Hypothesis were also tested to determine if or not the hypotheses might be instrumental in fraud and wastages occurrences in business organizations. In arriving at the data used, both primary and secondary data were used. The primary data includes questionnaires distributed to sampled staffs and management of May and Baker Plc and Drugfield Specialty Product Plc. The secondary data includes materials form published textbooks, internet, articles and newspapers. These were tested using Z-test statistics. Data were analyzed and some of the findings include inadequate …
Is the topic “Computerized Pay-as-you-go-call Billing System” recommended for Computer Science (CS) Project?
Yes it is highly recommended — Pay-as-you-go-call Billing System is a process of gathering call consumption data, calculating billing and charging information, availing customer bills, processing the customer payments as well as managing collection of debts. The aim of the study is to design and implement a Computerized Pay-as-you-go-call Billing System for effectiveness and ease of the problems facing the manual system. In achieving this aim, the following specific objectives were laid out to identify the problems that are encountered in the manual telephone System, ensure accuracy in the daily pay-as-you-call billing operations or activities, and detect sources of these errors and arrive at system that takes care of anomalies and give customers the best possible values of their money within the preparing cost constraints. The …
Is the topic “Design and Implementation of an Online Supermarket Shopping System” recommended for Computer Science (CS) Project?
Yes it is highly recommended — A Supermarket Shopping system is a software-based business solution used to simultaneously track sales activity and inventory. Computerized Supermarket Shopping systems save time for businesses by speeding up transactions while raising accuracy. The aim of the study is to design and implement an online application that will manage the Supermarket Shopping on goods and services. In achieving this aim, the following specific objectives were laid out to develop a website to aid easy ordering of products offered for sale and update stock level as they are being sold to enable the fast food restaurant to know when stock level is low. The motivation that led to the implementation of the proposed system is that, items are unknowingly out of stock, …
Can this topic “Obstacle to Effective Implementation of Policies in the Local Government System in Nigeria” be used for Public Administration (PA) Project?
Yes it can be utilized for research — Policy making and Implementation is one issue that cannot be over emphasized because of the important role it plays I the life of any organization wishing to survive and to grow in the face of changing world. Based on the need for organizations to achieve their objectives, the researcher decided to conduct research study on the obstacles to effective Implementation of policies in the local government system in Nigeria with a particular reference to Orlu LGA, Imo state. It has been observed that policy Implementation is one of the major problems confronting Nigeria since inception. Public policies therefore plays crucial role in the state and are equally instrumental to the develop or underdevelopment of any given state. Whereas, there has …
Can the material for “Comparative Study of Disinfectant Efficiency of Ethanol, Bleach and Phenolics Against Pseudomonas Aeruginosa and Staphylococcus Aureus” be used as a guide for Microbiology Project?
Yes it can be used — Ethanol, Bleach and Phenolics are three kinds of disinfectants which have been widely used in common laboratories. In this study, a compared experiment on these three disinfectants efficiency was conducted against Staphylococcus aureus and Pseudomonas aeruginosa using agar hole diffusion method. Different concentrations of bleach (1%, 2%, 3%, 4% and 5%) were used on both organisms. Also (50%, 60%, 70%, 85% and 95%) of ethanol as well as (5%, 10%, 20%, 25%, and 30%) Phenolics were used. Differences in concentrations tested was because, the original concentrations of the disinfectants differs. After 24 hours of incubation at 370C, the results showed that all the disinfectants inhibited the growth of the test organism in their concentrated forms. The diameter of zone of inhibitions …
Can the material for “Effect of Poor Health on the Academic Performance of Secondary School Students” be used as a guide for Health Education Project?
Yes it can be used — The study was carried out to investigate the Effect of Poor Health on the Academic Performance of Secondary School Students in Oredo Local Government Area of Edo State. In achieving this aim, the following specific objectives were laid out to determine whether the nature of the school administration has influence the healthy habit exhibited by students and examine the influence of health conditions on academic performance of Secondary School Students in the area under review. Investigation revealed that a lot of factors are responsible for the poor health on the Academic Performance of Secondary School Students. The negligence of the school health services by the responsible ministries is attributable to the low level of academic performance and absenteeism in Secondary …